+86 15538087991

using a lime kiln for calcining petroleum coke rotary

Production and Application of Calcined Coke In Rotary ...

2015-3-12  anodes for smelting of alumina to aluminum. Petroleum coke is usually calcined in a gas-fired rotary kiln or rotary hearth at high temperatures, around 1200 to 1450 °C, to remove moisture, drive off volatile matters, increase the density of the coke, increase physical strength, and electrical conductivity of the material.

More

Calcining petroleum coke of pot furnace and rotary kiln ...

2019-7-23  Calcining petroleum coke of pot furnace and rotary kiln. July 23, 2019 Retort calciner and rotary kiln are the two main types for petroleum coke calcination. Rotary kiln is widely used in Europe and the United States, while retort calciner is used earlier and more in China. There are great differences between the two in calcination process ...

More

Simulation of Combustion and Thermal-flow Inside a ...

2020-10-13  Simulation of Combustion and Thermal-flow Inside a Petroleum Coke Rotary Calcining Kiln . A Thesis Submitted to the Graduate Faculty of the University of New Orleans in partial fulfillment of the requirements for the degree of Master of Science in Mechanical Engineering by Zexuan Zhang B.S. University of New Orleans, 2003 May, 2007

More

2-2 Lime Kiln Principles and Operations

2008-1-4  8 Slide 15 Lime Kiln Heat Rate • Heat rate is a measure of energy efficiency – Units are MM Btu/ton CaO or GJ/tonne CaO – Often stated as MM Btu/ton “product” • Typical range – 5 to 9 MM Btu/ton CaO – 5.8 to 10.5 GJ/tonne CaO – Lower is better Slide 16 Lime Kiln Energy Balance Components • Drying • Calcining : CaCO3 + heat ÄCaO + CO2 • Losses – Heat loss

More

2-2 Lime Kiln Principles And Operations

2008-1-4  ROTARY LIME KILNS Slides 1 and 2 are the title and outline for the presentation. Slide 3, below, shows a schematic of the exterior of a modern rotary lime-reburning kiln. Slide 4 shows a schematic of the interior features of a lime-reburning kiln. Rotary lime kilns are large steel tubes that are lined on the inside with refractory bricks.

More

Using pet coke in a rotary kiln as fuel advantage ...

Pet coke handling system for lime kiln . pet coke for rotary lime kiln vigilfuocoponzone using a lime kiln for calcining petrolm coke stone grinding machine, grinding , using petcoke as primary fuel Pre , pet coke handling system for lime kiln pet coke effect of size of grinded petcoke in Read More. Oline Chat

More

Petroleum Coke Calcining Systems - Outotec

The petroleum green coke is fed into a refractory lined rotary kiln where the volatiles are driven off during the calcining process in an oxygen deficient atmosphere. Air can be injected through the kiln shell to burn a portion of the

More

INVESTIGATION OF COMBUSTION AND THERMAL

2013-3-25  calcined coke is the aluminum industry, at more than 70 % of the world’s total. Calcination is an energy intensive process. During the petcoke calcination, energy input is needed to heat up the petcoke and maintain the required calcining kiln temperature to produce the desired calcined petroleum coke quality.

More

Calcination of Limestone – IspatGuru

2013-5-2  calcination, lime, limestone, Long rotary kiln, preheater, reactivity, Rotary kiln, vertical kiln, Calcination of Limestone . Calcination or calcining is a thermal treatment process to bring about a thermal decomposition. The process takes place below the melting point of the product.

More

The History and Future Challenges of Calcined Petroleum ...

2014-12-20  Calcined petroleum coke is used for the production of carbon anodes in the Hall-Héroult aluminum smelting process due to a combination of low impurity levels, ready availability, and relatively low cost. This article provides a review of the history and use of calcined petroleum coke for anode production and describes the different calcining technologies used by the

More

Lining of the Rotary Kilns for Petroleum Coke Calcination ...

2019-8-10  A schematic diagram of the lining of a rotary kiln measuring 3.0 m in diameter and 45 m in length for calcining KEP-2 grade petroleum coke is shown in Fig. 4. The furnace is lined with a 250 mm thick layer of refractory material starting from the hot end.

More

Rotary Kiln Petroleum Coke Calcination Process Request

Request PDF Rotary Kiln Petroleum Coke Calcination Process Petroleum coke is a by-product of the coker process in the oil industry. In its raw form, it is also called “green coke” or green ...

More

Mathematical modeling of the rotary coke calcining kiln ...

A three‐dimensional steady‐state mathematical model of a rotary calcining kiln for the petroleum coke is presented. The model takes into account all

More

2-2 Lime Kiln Principles and Operations

2008-1-4  8 Slide 15 Lime Kiln Heat Rate • Heat rate is a measure of energy efficiency – Units are MM Btu/ton CaO or GJ/tonne CaO – Often stated as MM Btu/ton “product” • Typical range – 5 to 9 MM Btu/ton CaO – 5.8 to 10.5 GJ/tonne CaO – Lower is better Slide 16 Lime Kiln Energy Balance Components • Drying • Calcining : CaCO3 + heat ÄCaO + CO2 • Losses – Heat loss

More

2-2 Lime Kiln Principles And Operations

2008-1-4  ROTARY LIME KILNS Slides 1 and 2 are the title and outline for the presentation. Slide 3, below, shows a schematic of the exterior of a modern rotary lime-reburning kiln. Slide 4 shows a schematic of the interior features of a lime-reburning kiln. Rotary lime kilns are large steel tubes that are lined on the inside with refractory bricks.

More

CN101676364B - Calcining process of petroleum cokes by ...

The invention relates to a calcining process of petroleum cokes and equipment, in particular to a calcining process of petroleum cokes by using a large rotary kiln. The process adopts the unique process of first grinding and then sieving the petroleum cokes and the technology of quantitatively feeding materials to the rotary kiln. A cooler is used for cooling the cokes calcined at high ...

More

SIMULATION OF COMBUSTION AND THERMAL-FLOW

2013-3-25  SIMULATION OF COMBUSTION AND THERMAL-FLOW INSIDE A PETROLEUM COKE ROTARY CALCINING KILN, PART 2: ANALYSIS OF EFFECTS OF TERTIARY AIRFLOW AND ROTATION Zexuan Zhang Ting Wang Research Assistant Professor [email protected] [email protected] Energy Conversion and Conservation Center University of New Orleans

More

INVESTIGATION OF COMBUSTION AND THERMAL

2013-3-25  calcined coke is the aluminum industry, at more than 70 % of the world’s total. Calcination is an energy intensive process. During the petcoke calcination, energy input is needed to heat up the petcoke and maintain the required calcining kiln temperature to produce the desired calcined petroleum coke quality.

More

Investigation of Combustion and Thermal-Flow Inside a ...

2012-8-1  Simulation of Combustion and Thermal-Flow Inside a Petroleum Coke Rotary Calcining Kiln—Part II: Analysis of Effects of Tertiary Airflow and Rotation. J. Thermal Sci. Eng. Appl (June,2010) Investigation of Potential Benefits of Using Bricks of High Thermal Capacity and Conductivity in a Rotating Calcining Kiln.

More

Calcination of Limestone – IspatGuru

2013-5-2  calcination, lime, limestone, Long rotary kiln, preheater, reactivity, Rotary kiln, vertical kiln, Calcination of Limestone . Calcination or calcining is a thermal treatment process to bring about a thermal decomposition. The process takes place below the melting point of the product.

More

2-2 Lime Kiln Principles and Operations

2008-1-4  8 Slide 15 Lime Kiln Heat Rate • Heat rate is a measure of energy efficiency – Units are MM Btu/ton CaO or GJ/tonne CaO – Often stated as MM Btu/ton “product” • Typical range – 5 to 9 MM Btu/ton CaO – 5.8 to 10.5 GJ/tonne CaO – Lower is better Slide 16 Lime Kiln Energy Balance Components • Drying • Calcining : CaCO3 + heat ÄCaO + CO2 • Losses – Heat loss

More

EProduction and Application of Calcined Coke In Rotary ...

Calcined coke is the best material for making carbon anodes for smelting of alumina to aluminum. Petroleum coke is usually calcined in a gas-fired rotary kiln or rotary hearth at high temperatures ...

More

how to use pet coke with lime stone

Using pet coke in a rotary kiln as fuel advantage. Pet coke handling system for lime kiln . pet coke for rotary lime kiln vigilfuocoponzone using a lime kiln for calcining petrolm coke stone grinding machine, grinding,using petcoke as primary fuel Pre,pet coke handling system for lime kiln pet coke effect of size of grinded petcoke in Read More.

More

2-2 Lime Kiln Principles And Operations

2008-1-4  ROTARY LIME KILNS Slides 1 and 2 are the title and outline for the presentation. Slide 3, below, shows a schematic of the exterior of a modern rotary lime-reburning kiln. Slide 4 shows a schematic of the interior features of a lime-reburning kiln. Rotary lime kilns are large steel tubes that are lined on the inside with refractory bricks.

More

SIMULATION OF COMBUSTION AND THERMAL-FLOW

2013-3-25  SIMULATION OF COMBUSTION AND THERMAL-FLOW INSIDE A PETROLEUM COKE ROTARY CALCINING KILN, PART 2: ANALYSIS OF EFFECTS OF TERTIARY AIRFLOW AND ROTATION Zexuan Zhang Ting Wang Research Assistant Professor [email protected] [email protected] Energy Conversion and Conservation Center University of New Orleans

More

Mathematical modeling of the rotary coke calcining kiln ...

A three‐dimensional steady‐state mathematical model of a rotary calcining kiln for the petroleum coke is presented. The model takes into account all the physical phenomena of interest, from gas flow, heat transfer, volatile matter and coke dust evolution and combustion, to the granular bed motion and the thermal effects of the refractories.

More

Investigation of Combustion and Thermal-Flow Inside a ...

2012-8-1  Simulation of Combustion and Thermal-Flow Inside a Petroleum Coke Rotary Calcining Kiln—Part II: Analysis of Effects of Tertiary Airflow and Rotation. J. Thermal Sci. Eng. Appl (June,2010) Investigation of Potential Benefits of Using Bricks of High Thermal Capacity and Conductivity in a Rotating Calcining Kiln.

More

Thermal-flow Inside a Petroleum Coke Rotary Calcining Kiln

2012-7-28  Thermal-flow Inside a Petroleum Coke Rotary Calcining Kiln. Posted Jul 14, 2012, 12:16 a.m. EDT Fluid, Heat Transfer Phase Change, Computational Fluid Dynamics (CFD), Chemical Reaction Engineering, Materials, Mesh, Parameters, Variables, Functions, Studies Solvers Version 4.0 5 Replies

More

Simulation of Combustion and Thermal-Flow Inside a ...

2010-10-28  A computational model is established to simulate the combustion and thermal-flow behavior inside a petcoke rotary calcining kiln. The results show that peak temperature is located at the tertiary air zone and a cold region that exists between the natural gas combustion zone and the tertiary air zone causes the coke bed to lose heat to the gas stream.

More

CB01 - Anhydrous Carbon Pellets – An Engineered CPC

2019-10-10  In 2011, Rain Carbon started to experiment with the agglomeration of green petroleum coke (GPC) fines as a way to improve calcining economics. When a rotary kiln is used for calcining, around 10% of the finest particle size GPC becomes entrained in the counter-current flue gas stream inside the kiln.

More